System Service & Repair
The details mentioned below will help you out.
NOTE
It is recommended that the A/C system be serviced by an EPA Section 609 certified automotive technician utilizing a refrigerant recovery/recycling machine.
The do-it-yourselfer should not service his/her own vehicle's A/C system for many reasons, including legal concerns, personal injury, environmental damage and cost. The following are some of the reasons why you may decide not to service your own vehicle's A/C system.
According to the U.S. Clean Air Act, it is a federal crime to service or repair (involving the refrigerant) a Motor Vehicle Air Conditioning (MVAC) system for money without being EPA certified. It is also illegal to vent R-12 and R-134a refrigerants into the atmosphere. Selling or distributing A/C system refrigerant (in a container which contains less than 20 pounds of refrigerant) to any person who is not EPA 609 certified is also not allowed by law.
State and/or local laws may be more strict than the federal regulations, so be sure to check with your state and/or local authorities for further information. For further federal information on the legality of servicing your A/C system, call the EPA Stratospheric Ozone Hotline.
NOTE
Federal law dictates that a fine of up to $25,000 may be levied on people convicted of venting refrigerant into the atmosphere. Additionally, the EPA may pay up to $10,000 for information or services leading to a criminal conviction of the violation of these laws.
When servicing an A/C system you run the risk of handling or coming in contact with refrigerant, which may result in skin or eye irritation or frostbite. Although low in toxicity (due to chemical stability), inhalation of concentrated refrigerant fumes is dangerous and can result in death; cases of fatal cardiac arrhythmia have been reported in people accidentally subjected to high levels of refrigerant. Some early symptoms include loss of concentration and drowsiness.
NOTE
Generally, the limit for exposure is lower for R-134a than it is for R-12. Exceptional care must be practiced when handling R-134a.
Also, refrigerants can decompose at high temperatures (near gas heaters or open flame), which may result in hydrofluoric acid, hydrochloric acid and phosgene (a fatal nerve gas).
R-12 refrigerant can damage the environment because it is a Chlorofluorocarbon (CFC), which has been proven to add to ozone layer depletion, leading to increasing levels of UV radiation. UV radiation has been linked with an increase in skin cancer, suppression of the human immune system, an increase in cataracts, damage to crops, damage to aquatic organisms, an increase in ground-level ozone, and increased global warming.
R-134a refrigerant is a greenhouse gas which, if allowed to vent into the atmosphere, will contribute to global warming (the Greenhouse Effect).
It is usually more economically feasible to have a certified MVAC automotive technician perform A/C system service on your vehicle. Some possible reasons for this are as follows:
While it is illegal to service an A/C system without the proper equipment, the home mechanic would have to purchase an expensive refrigerant recovery/recycling machine to service his/her own vehicle.Since only a certified person may purchase refrigerant-according to the Clean Air Act, there are specific restrictions on selling or distributing A/C system refrigerant-it is legally impossible (unless certified) for the home mechanic to service his/her own vehicle. Procuring refrigerant in an illegal fashion exposes one to the risk of paying a $25,000 fine to the EPA.
---------
Thanks.
---------
No comments:
Post a Comment